F250 extended cab rear door wont open




F250 extended cab rear door wont open

Article Navigation:
  • Photo
  • SuperCab rear doors won't open. Cable / Latch broken - Ford Truck Enthusiasts Forums
  • Video
  • RELATED PAGES
  • - L Power Stroke Diesel - SuperCab rear doors won't open. Cable / Latch broken - A while back one of my supercab doors would.

    By pushing on the lever inside this area, the latch will release. Push on the door at the same time, when the latch is pushed. With the door open.

    Door won't open - My Ford F extended cab back passenger side door won't open l f extend cab rear door wont open 1 Answer.

    F250 extended cab rear door wont open

    F250 extended cab rear door wont open

    With the door open, remove all four screws from the plastic panel. Not finding what you are looking for? Thanks for all of the replies A twenty minute job. Remove the upper rear door latch.

    F250 extended cab rear door wont open

    F250 extended cab rear door wont open

    F250 extended cab rear door wont open

    F250 extended cab rear door wont open

    F250 extended cab rear door wont open

    Ford Rear Doors Wont Open - HD Repair Video Tutorials

    Like the site so far? SuperCab rear doors won't open. A while back one of my supercab doors would no longer open. I was able to follow the instructions here and fix it. A year or so later, the lower cable broke. Here's how I fixed it. There is another post with some drilling and rivets.

    The main cause of problems with stuck doors is that all the cables use plastic bushings to hold the cable into the proper position. Apparently, this plastic degrades over time and disintegrates, causing the cable to no longer be anchored where it should be. This repair is just re-securing the cables to their proper position. Pull the top half of the door panel off towards you.

    F250 extended cab rear door wont open

    For the lower panel, there are two 7mm bolts and possible a screw. Remove them and lift the lower panel straight up to remove. You can now use a screwdriver to unlatch the lower door catch.

    To open it, you need to leverage the screw driver to mimic pulling the cable. It may take you a couple of times to get it right. If the upper latch is also broken, you can unlatch it by just pulling down on the upper cable. I had to pull down on the upper cable and use the screwdriver on the lower latch at the same time to open the door. Once the door is open, use a T27 screwdriver to remove the 3 screws at the bottom of the door holding the latch in place.

    F250 extended cab rear door wont open

    Then you can remove it and work on it much easier. All I did was cut and trim a simple plastic screw wall anchor to mimic the original size and shape of the plastic bushing.

    I then used zip ties to hold it in place. When you have it secured, just remount the lower latch and you are good to go. If you top latch is also bad, you can use the zip ties to anchor the cable in the proper position. Here are some pics. The original disintegrated bushing. Use a razor knife to remove it. The plastic screw anchor used to replace bushing.

    Cut it to size. Anchor the plastic screw anchor to the cable with zip ties. Insert the ball end of the cable to the lower latch and then secure the cable with 1 more anchor. Used a couple of zip ties to secure the upper cable into its proper place. Here is a fuzzy picture of the lower latch remounted in the door, with the zip tied cable in place. Find all posts by bigtexan Good info and pics. Find all posts by diesel-fitter-bum Did you get your door to work long term?

    F250 extended cab rear door wont open

    Sounds like the fix on this page combined with the info in the video below should fix my problem. I had the same problem with my upper latch.

    Turned out to be a broken cable sheath. I wouldn't think the zip tie would work long term, but it is worth a try. This guy made a video about a different way to fix it. I haven't tried it yet. Just looking around for ideas before I start. Be sure to click a few ads if you like the guys video. It was a three part video. Takes a little effort to rig yourself. I think the bottom cable is pretty similar. Find all posts by bradxray.

    extended cab doors wont open on 2001 f250



    • Подписаться по RSSRSS
    • Поделиться VkontakteVkontakte
    • Поделиться на FacebookFacebook
    • Твитнуть!Twitter

    Leave a Reply

    Return to Top ▲TOP ▲